- ICH GCP
- US Clinical Trials Registry
- Clinical Trial NCT06042062
Clinical Evaluation of Infection Control to Knee Periprosthetic Joint Infection (PJI) -United Cellbrick Knee Spacer
Study Overview
Status
Conditions
Intervention / Treatment
Detailed Description
Two-stage exchange arthroplasty, which involves the removal of infected prostheses and introduction of a temporary antibiotic-loaded cement spacers at the infection site, has been widely accepted among treatment options. Antibiotic-loaded cement spacers facilitate in maintaining joint space, limb length, soft tissue tension, and lengthening the period of effective antibiotic release until infection control has been accomplished.
Although articulating knee spacers have demonstrated advantages in joint mobility and clinically successful rates in infection control, issues relating to biomechanical safety contributed by cement material characteristics have been noted. Surgeons had to implement alternative methods for the construction of an intramedullary spacer to provide sufficient infection control for deeper infection sites which could cause surgical inconveniences. A novel polyethylene-based knee spacer, for the purpose of infection control, was developed to enhance biomechanical safety and surgical convenience of articulating knee spacers.
The investigators aim to conduct a clinical study comparing the use of Articulating Spacers to United Cellbrick Knee Spacers in a practical setting to better understand the safety and performance of United Cellbrick Knee Spacers and to enhance the clinical confidence of investigators. A total of 10 participants who are undergoing two-stage exchange arthroplasty at Linkou Changgung Memorial Hospital will be recruited, including 5 participants in the "Spacer" group and 5 participants in the "Novel Spacer" group.
Participants in the "Spacer" group will receive a full-cement spacer (Stryker, Simplex P) made of broad-acting antibiotics (Vancomycin and Gentamicin) produced in the hospital.
Participants in the "Novel Spacer" group will receive a United Cellbrick Knee Spacer, where the femoral and tibial spacers will be filled with bone cement (Stryker Simplex P) with antibiotics (Vancomycin and Gentamicin).
Spacer survivorship defined as no removal or revision of any components as a result of mechanical failure or complications will be analyzed. Blood tests, joint effusions, and x-ray inspections will also be collected for analysis.
Study Type
Enrollment (Estimated)
Phase
- Not Applicable
Contacts and Locations
Study Contact
- Name: Yu-Han Chang, MD, PhD
- Phone Number: 2420 886-3-3281200
- Email: yhchang@adm.cgmh.org.tw
Study Locations
-
-
-
Taoyuan, Taiwan, 333
- Recruiting
- Department of Orthopedic Surgery at Linkou Changgung Memorial Hospital
-
Contact:
- Yu-Han Chang, MD, PhD
- Phone Number: 2420 886-3-3281200
- Email: yhchang@adm.cgmh.org.tw
-
Principal Investigator:
- Yu-Han Chang, MD, PhD
-
-
Participation Criteria
Eligibility Criteria
Ages Eligible for Study
- Adult
- Older Adult
Accepts Healthy Volunteers
Study Population
Description
Inclusion Criteria
Patients who are 18 years of age or older, suitable for temporary knee joint implants, and will be undergoing treatment in Linkou Chang Gung Memorial Hospital who meet the following criteria and have skeletally mature bones:
- Patients who are diagnosed with infection before surgery and are expected to undergo two-stage procedure for total knee replacement (TKR);
- Patients who are willing to use traditional mobility aids (such as crutches, walkers) during implantation;
- The implantation time of the temporary knee implant shall not exceed 180 days.
Exclusion Criteria
- Patients who are allergic to or have suffered from allergies to any component of the implant, the bone cement used together or antibiotics.
- Patients who cannot perform two-stage knee replacement surgery due to decreased immune response or other relevant clinical conditions.
- Patients who have not previously received total knee replacement surgery, and the secondary infection is caused by trauma, septic arthritis or other surgery.
- Sufficient support and / or fixation for implants due to disease, soft tissue defects, bone defects or other relevant clinical conditions.
- Inability or unwillingness to return to hospital for evaluation.
- Cognitive function impairment makes the subject unable to answer questions or cooperate with instructions.
- Other systemic comorbidities lead to severe impairment of the subject's mobility and function.
Study Plan
How is the study designed?
Design Details
- Primary Purpose: Treatment
- Allocation: Randomized
- Interventional Model: Parallel Assignment
- Masking: None (Open Label)
Arms and Interventions
Participant Group / Arm |
Intervention / Treatment |
---|---|
Experimental: "Spacer" group
The subjects who are assigned to Articulating Spacers in two-stage exchange arthroplasty.
|
After diagnosis of infection and informed consent, patients will be taken to the operating room.
After anesthetization, patients will be randomized to either a Cellbrick spacer (United Orthopedic Corporation, Taiwan) or an articulating full-cement spacer.
Randomization will be performed by prepared opaque envelopes administered by a nonparticipant in the study.
After a complete debridement of devitalized tissue, explantation of the infected components and any associated cement, either an United Cellbrick spacer or an Articulating Spacer will be placed.
The Articulating Spacer will be hand-made to fit the femoral and tibial exposed metaphyses as a solid block with associated antibiotic loaded bone cement (ALBC).
The ALBC will be formed from an antibiotic mixture of Vancomycin and Gentamicin with bone cement (Stryker, Simplex P).
|
Experimental: "Novel spacer" group
The subjects who are assigned to United Cellbrick Knee Spacer in two-stage exchange arthroplasty.
|
After diagnosis of infection and informed consent, patients will be taken to the operating room.
After anesthetization, patients will be randomized to either a United Cellbrick spacer (United Orthopedic Corporation, Taiwan) or an articulating full-cement spacer.
Randomization will be performed by prepared opaque envelopes administered by a nonparticipant in the study.
After a complete debridement of devitalized tissue, explantation of the infected components and any associated cement, either a Cellbrick spacer or an articulating spacer will be placed.
As for the United Cellbrick spacer, antibiotic loaded bone cement (ALBC) will be molded into the designed holes (fenestrations).
The ALBC will be formed from an antibiotic mixture of Vancomycin and Gentamicin with bone cement (Stryker, Simplex P).
|
What is the study measuring?
Primary Outcome Measures
Outcome Measure |
Measure Description |
Time Frame |
---|---|---|
Success Rate
Time Frame: up to 6 months following surgery
|
Failure is defined as removal or revision of any components as a result of mechanical failure or complications. Success is defined as implants that are successfully implanted without any failure for the duration of up to 180 days. *Note: Spacers are temporarily implanted into patients for any two-stage arthroplasty. Hence, upon assessment by the surgeon, when the condition of the patients are ideal for the second-stage arthroplasty procedure, the surgeon will remove the spacer accordingly. Therefore, the timeframe for the spacer removal may happen anywhere before the duration of 180 days. The success rate will be represented as a percentage (%). |
up to 6 months following surgery
|
Secondary Outcome Measures
Outcome Measure |
Measure Description |
Time Frame |
---|---|---|
Vancomycin Concentration
Time Frame: Day 1, 3, 7, up to 6 months following surgery
|
Vancomycin Concentration will be quantified utilizing Particle Enhanced Turbidimetric Inhibition Immunoassay.
Blood samples (3mL) and joint effusion samples (5-10cc) will both be used to analyze the efficacy of vancomycin concentration (5-15ug/mL).
|
Day 1, 3, 7, up to 6 months following surgery
|
Gentamycin Concentration
Time Frame: Day 1, 3, 7, up to 6 months following surgery
|
Gentamycin Concentration will be quantified utilizing Particle Enhanced Turbidimetric Inhibition Immunoassay.
Blood samples (3mL) and joint effusion samples (5-10cc) will both be used to analyze the efficacy of gentamycin concentration (5-15ug/mL).
|
Day 1, 3, 7, up to 6 months following surgery
|
C-reactive protein assessment
Time Frame: Baseline, 7, up to 6 months following surgery
|
C-reactive protein assessment will be quantified utilizing turbidimetric-immunoassay. Blood samples (3mL) will be used to determine the level of inflammation.
|
Baseline, 7, up to 6 months following surgery
|
Bioassay of Antibiotic Activity of in Vitro Samples
Time Frame: Day 1, 2, 3, 7
|
Bioassay of Antibiotic Activity of in Vitro Samples will be quantified utilizing aliquots of the samples and a modified microtube dilution bioassay.
The following strains were selected as test organisms: Methicillin-susceptible Staphylococcus aureus (MSSA, ATCC 25923), Methicillin-resistant Staphylococcus aureus (MRSA, ATCC 43300), Staphylococcus epidermidis (ATCC 14990), Pseudomonas aeruginosa (P.
aeruginosa, ATCC 27853) or Escherichia coli (E.
coli, ATCC 25922).
The in vitro samples were were inoculated with 105 colony forming units (CFUs) of bacteria per milliliter in 96-well culture dishes and incubated at 37 degree Celsius for 24 hours according to Hsu et al.
The growth of bacteria associated with the different concentrations of antibiotics was compared visibly with each other and against the positive control (without antibiotic).
The minimum inhibitory concentration of each antibiotic against each bacterium was determined by microtube dilution bioassay.
|
Day 1, 2, 3, 7
|
Spacer Complications
Time Frame: Baseline, Day 0, up to 6 months following surgery
|
Any issues with spacer complications including allergic reactions, bone loss, joint stiffness, wound complications, recurrence or persistence of the infection, spacer fracture or dislocation, and side effects of local or systemic antibiotics will be recorded.
|
Baseline, Day 0, up to 6 months following surgery
|
Collaborators and Investigators
Sponsor
Collaborators
Investigators
- Principal Investigator: Yu-Han Chang, MD, PhD, Chang Gung memorial hospital
Study record dates
Study Major Dates
Study Start (Actual)
Primary Completion (Estimated)
Study Completion (Estimated)
Study Registration Dates
First Submitted
First Submitted That Met QC Criteria
First Posted (Actual)
Study Record Updates
Last Update Posted (Actual)
Last Update Submitted That Met QC Criteria
Last Verified
More Information
Terms related to this study
Additional Relevant MeSH Terms
Other Study ID Numbers
- 202300966A3
Drug and device information, study documents
Studies a U.S. FDA-regulated drug product
Studies a U.S. FDA-regulated device product
product manufactured in and exported from the U.S.
This information was retrieved directly from the website clinicaltrials.gov without any changes. If you have any requests to change, remove or update your study details, please contact register@clinicaltrials.gov. As soon as a change is implemented on clinicaltrials.gov, this will be updated automatically on our website as well.
Clinical Trials on Knee; Infection, Joint
-
Northwestern UniversityNot yet recruitingArthroplasty, Replacement, Knee | Arthroplasty Complications | Joint Infection | Prosthetic-joint Infection | Knee InfectionUnited States
-
Leiden University Medical CenterRadboud University Medical Center; University Medical Center Groningen; Erasmus... and other collaboratorsRecruitingProsthetic-joint Infection | Infection Hip | Infection; Knee, JointNetherlands
-
Charite University, Berlin, GermanyUnknownHip Prosthetic Joint Infection | Knee Prosthetic Joint Infection | Shoulder Prosthetic Joint Infection
-
Rigshospitalet, DenmarkThe Lundbeck Foundation Centre for Fast-track Hip and Knee ArthroplastyCompletedInfection of Total Knee Joint ProsthesisDenmark
-
Technical University of MunichUnknownInfection of Total Knee Joint ProsthesisGermany
-
Mayo ClinicTerminatedProsthetic Joint Infection of the KneeUnited States
-
Pherecydes PharmaRecruitingInfection of Total Hip Joint Prosthesis | Infection of Total Knee Joint ProsthesisFrance
-
Vastra Gotaland RegionGöteborg UniversityRecruitingProsthetic Joint Infection | Hip Prosthesis Infection | Prosthetic Infection | Knee Prosthesis InfectionSweden
-
Alberta Hip and Knee ClinicUniversity of CalgaryNot yet recruitingInfection of Total Hip Joint Prosthesis | Infection of Total Knee Joint Prosthesis
-
Zimmer BiometCompletedInfection of Total Knee Joint ProsthesisUnited States
Clinical Trials on Spacer
-
University of OuluOulu University HospitalTerminatedUrogenital Neoplasms | Neoplasms by Site | Genital Neoplasms, Male | Prostatic NeoplasmsFinland
-
Globus Medical IncTerminatedLumbar Spinal StenosisUnited States
-
Spineology, IncCompletedDegeneration of Lumbar Intervertebral DiscUnited States
-
University of CologneTerminatedLumbar Spinal StenosisGermany
-
Artimplant ABUnknown
-
Northwestern UniversityNot yet recruitingArthroplasty, Replacement, Knee | Arthroplasty Complications | Joint Infection | Prosthetic-joint Infection | Knee InfectionUnited States
-
University Medical Center GroningenTrudell Medical InternationalNot yet recruiting
-
Peking Union Medical College HospitalShanghai Reunion Biotech Co.,Ltd.RecruitingUterine Cervical NeoplasmsChina
-
Montefiore Medical CenterRecruiting
-
Rush University Medical CenterThomas Jefferson University; Central DuPage Hospital; Joint Implant Surgeons,...CompletedOsteoarthritis | Prosthetic Joint Infection | Complications; Arthroplasty | Complications; Arthroplasty, Infection or Inflammation | Knee InfectionUnited States