Time and Cost-implications of Intraoral Scans Vs Alginate Impressions

February 28, 2025 updated by: University of Sheffield

Time and Cost-implications of Intraoral Scans Vs Alginate Impressions: a Randomised Controlled Trial

BACKGROUND: Alginate impressions have long been a staple in orthodontics, but with recent technological advancements, digital impressions via intraoral scans are gaining increasing popularity. While much research has focused on patient preference and the accuracy of these techniques, there is a notable gap in the literature regarding chair side time and associated costs. Existing studies on chair side time comparisons between alginate impressions and intraoral scanning yield inconsistent results, underscoring the need for further investigation. This study aimed to evaluate the chair side time and cost implications of intraoral scanning and alginate impressions.

OBJECTIVES: The primary objective is to compare the chair side time taken for alginate impressions and intraoral scanning of orthodontic patients aged 9 years and over in an orthodontic department at a district general hospital. The secondary objective is to evaluate the costs associated with alginate impressions and intraoral scanning of orthodontic patients described above.

DESIGN, SETTING AND PARTICIPANTS: A prospective, single-centre, parallel-arm randomised controlled trial (1:1 allocation) to be undertaken in a district general hospital. Sixty-eight orthodontic patients aged nine and above, requiring study models, will be recruited during new patient appointments at the Orthodontic Department at Queen's Medical Centre, Nottingham. Patients will be randomly assigned to either the intraoral scan or alginate impression group, with chair side time recorded for each procedure, including retakes. The IOS group will use the 3Shape TRIOS scanner, while the alginate group will follow standard procedures. The costs of each technique will be calculated following the procedure. Ethical approval was obtained from a Health Research Authority Research Ethics Committee.

OUTCOMES: N/A

CONCLUSIONS: N/A

Study Overview

Status

Not yet recruiting

Conditions

Intervention / Treatment

Detailed Description

RATIONALE: This research project investigates the evolving landscape of orthodontic practices by comparing the time and cost implications of two prevalent techniques: intraoral scanning and traditional alginate impressions.

Whilst the majority of the existing literature reveals patient preference in favour of intraoral scanning, it remains common practice to use alginate impressions for orthodontic records. Considerations such as time implications, device costs, associated software expenses, and the need for clinician training pose challenges to widespread adoption of intraoral scanning. When comparing chairside time taken for intraoral scans versus alginate impressions, there are inconsistent findings, necessitating a comprehensive investigation.

The outcomes of this study will provide crucial insights into the practicality and economic viability of intraoral scanning versus alginate impressions in orthodontic settings, thereby informing clinical practices and facilitating technological assimilation within the United Kingdom. This research contributes to strengthening the evidence base surrounding orthodontic techniques and their implications for patient-centred care.

DESIGN: Prospective single-centre parallel-arm randomised controlled trial, with an allocation ratio of 1:1, to investigate the difference in chair side time and cost of alginate impressions vs intraoral scans.

SETTING: A single-centre study was undertaken in the Orthodontic Department at Queens Medical Centre (QMC), Nottingham University Hospitals NHS Trust.

EXCLUSION CRITERIA:

  • Patients who will not be undergoing orthodontic treatment in secondary care (referral back to primary care).
  • Patients who refuse to consent to inclusion in the trial.
  • Patients with contraindications to either impression method (e.g., severe gag reflex, claustrophobia, medical history that would preclude the taking of dental impressions).
  • Patients with severe dental anxiety.
  • Patients with cleft lip and/or palate.

RECRUITMENT: Orthodontic patients aged 9 years and above attending the orthodontic department at Nottingham University Hospital for a new patient assessment will be assessed by an appropriately trained clinician for their eligibility for inclusion in the trial.

CONSENT: The Chief Investigator (CI) retains overall responsibility for the conduct of research, including the taking of informed consent of patients. The CI must ensure that any person delegated responsibility to participate in the informed consent process is duly authorised, trained and competent to participate according to the ethically approved protocol, principles of Good Clinical Practice (GCP) and Declaration of Helsinki.

The clinician will carry out a screening process consisting of a written checklist to assess whether patients meet the inclusion criteria. Following the identification of eligible patients, the trial will be discussed in more detail with the potential patient and/or their parent/guardian. Discussion of the trial will be undertaken by a clinician trained in the REC-approved research protocol. The discussion will involve the following:

  • Introduction

    • An explanation to the patient and their parent/guardian as to the purpose and the nature of the research
    • An outline of what the research involves.

  • Involvement

    o What would be required by the patient / their child.

  • Benefits

    • Discussion of any potential benefits that may be involved.
  • Risks o Discussion of any potential risks that may be involved.

  • Alternatives

    o Discussion of the alternative options should the patient and/or their parent/guardian not want to take part in the trial.

  • Withdrawal

    • Should the patient and/or their parent/guardian wish to withdraw from the study, they may do so at any time and do not have to give a reason as to why they are withdrawing.
    • It will be emphasised that should the patient and/or their parent/guardian choose to withdraw from the study, this will not impact the care they receive.

  • Questions

    o The patient and/or their parent/guardian will be allowed to ask any questions they may have related to the trial.

  • Capacity

    • The capacity of the patients shall be assessed.
    • Patients over the age of 16 may consent to inclusion in the trial should they have the capacity to do so.
  • Contact o Information regarding a point of contact for the trial will be given to the patient and/or their parent/guardian.

Any patients who meet the exclusion criteria will not be included in the trial. Following a verbal discussion of the trial, the patient and/or their parent/guardian will be provided with a patient information sheet and given the opportunity to ask any questions before deciding if they would provisionally like to enrol in the trial.

At the beginning of the next visit, the patient's and/or their parent's/guardian's consent to inclusion in the trial will be confirmed. Should the patient and/or their parent/guardian consent to inclusion, the patient will be enrolled in the trial and randomly allocated to a treatment group (either alginate impression or intraoral scan). Informed consent must be obtained before the patient undergoes procedures that are specifically for the trial.

Should the patient and/or their parent/guardian decline to participate in the trial, they will continue with their normal orthodontic treatment and not receive any further information regarding the trial. For children under the age of 16 years, assent will be sought from their parent/guardian. Adults who are unable to consent will not be included in the trial.

Should a patient and/or their parent/guardian wish to withdraw from the trial, they may do so at any point and do not have to stipulate as to why. Patients and/or their parents/guardians will be reassured that withdrawal from the trial will not affect their treatment.

Refusal from the patient to take part in the trial must be respected, and no reason is required. Patients remain free to withdraw from the trial at any time without stipulating why and without prejudicing their further treatment. Patients must be provided with a contact point where they may obtain further information about the trial. Data collected up to the point of withdrawal can only be used after withdrawal if the patient has consented to this.

TRIAL: Once consent has been gained and the patient has been randomly allocated to a treatment group, one of the following procedures will be followed:

Intraoral scanner group

  • The 3Shape TRIOS unit will be set up, tip warmed, and patient details entered into the system.
  • Timer started: A timer will be started by the dental nurse when the 3Shape TRIOS unit is removed from the holder by the clinician.
  • The clinician will complete the scan in the order on the system (lower arch, upper arch and bite registration) and save it to the system.
  • Timer stopped: Once the scan taken is of good quality, the clinician will place the 3Shape TRIOS unit back in the holder, and the dental nurse will stop the timer.
  • The clinician will check the quality of the scan against example photos, which will demonstrate good quality scans. If the scan does not meet these quality standards, it will require a retake. If any retakes are required, the timer will be resumed, and the procedure will be carried out as above.
  • The time taken for the procedure and the number of retakes required will be recorded in the data collection section of the case report form (CRF).

Alginate impression group

  • The clinical area will be set up with the appropriate equipment- alginate, water, mixing bowl, spatula, measuring cup, upper and lower trays, adhesive and wax.
  • The clinician will check the appropriate tray sizes for the patient.
  • The timer started: A timer will be started by the dental nurse when the water for the alginate impression is poured into the mixing bowl.
  • The upper and lower impressions will be taken.
  • A wax bite registration will then be taken.
  • Timer stopped: The timer will be stopped by the dental nurse when the bite registration is removed from the patient's mouth and placed in the designated area on the worktop.
  • The clinician will check the quality of the impressions and bite registration against example photos, which will demonstrate good quality impressions/bite registration. If the impressions or bite registration does not meet these quality standards, then they will require a retake. If any retakes are required, the timer will be resumed, and the procedure will be carried out as above.
  • The time taken for the procedure, a number of scoops of alginate used and the number of retakes required will be recorded in the data collection section of the CRF.

Measurements taken will only include the chairside time taken to make the impression and will not include time taken for disinfection and processing of impressions.

ANALYSES: Tests for normality will be used to determine whether the data is normally distributed. If the data is normally distributed and with equal variances between the two groups, then a two-sided independent t-test will be used. If the data is not normally distributed, a Mann-Whitney U test will be used.

Study Type

Interventional

Enrollment (Estimated)

68

Phase

  • Not Applicable

Contacts and Locations

This section provides the contact details for those conducting the study, and information on where this study is being conducted.

Study Contact

Study Contact Backup

Study Locations

Participation Criteria

Researchers look for people who fit a certain description, called eligibility criteria. Some examples of these criteria are a person's general health condition or prior treatments.

Eligibility Criteria

Ages Eligible for Study

  • Child
  • Adult
  • Older Adult

Accepts Healthy Volunteers

Yes

Description

Inclusion Criteria:

  • Orthodontic patients aged 9 years and above requiring study models, having attended the orthodontic department at Nottingham University Hospitals for a new patient assessment.

Exclusion Criteria:

  • Patients who will not be undergoing orthodontic treatment in secondary care (referral back to primary care).
  • Patients who refuse to consent to inclusion in the trial.
  • Patients with contraindications to either impression method (e.g., severe gag reflex, claustrophobia, medical history that would preclude the taking of dental impressions).
  • Patients with severe dental anxiety.
  • Patients with cleft lip and/or palate.

Study Plan

This section provides details of the study plan, including how the study is designed and what the study is measuring.

How is the study designed?

Design Details

  • Primary Purpose: Health Services Research
  • Allocation: Randomized
  • Interventional Model: Parallel Assignment
  • Masking: Single

Arms and Interventions

Participant Group / Arm
Intervention / Treatment
Active Comparator: Alginate impression
Procedure: Alginate impression
Alginate impressions are a traditional method for creating dental moulds which are used in orthodontic records. Plastic trays are sized to fit the upper and lower jaws, and the alginate is mixed into a putty before being placed in the trays. The putty is then used to take detailed impressions of the patient's teeth. To capture an accurate bite registration, the patient bites down on a piece of warmed wax.
Active Comparator: Intraoral scan
Intraoral scan using Trios 3Shape Scanner
Procedure: Intraoral scan
Intraoral scanners capture multiple images of the mouth, which are combined to create a three-dimensional model of the patient's upper and lower teeth. The scanning wand is passed methodically over the surface of the teeth to gather all the necessary information, which is displayed in real-time on a computer screen.

What is the study measuring?

Primary Outcome Measures

Outcome Measure
Measure Description
Time Frame
Chairside time taken for alginate impressions vs intraoral scans.
Time Frame: 12 months
To compare the mean chairside time taken for alginate impression taking and intraoral scanning of orthodontic patients aged 9 years and over, in an orthodontic department at a district general hospital.
12 months

Secondary Outcome Measures

Outcome Measure
Measure Description
Time Frame
Cost implications of alginate impressions vs intraoral scans.
Time Frame: 12 months
Evaluation of the costs associated with alginate impressions and intraoral scanning of orthodontic patients described above.
12 months

Collaborators and Investigators

This is where you will find people and organizations involved with this study.

Sponsor

University of Sheffield

Collaborators

Nottingham University Hospitals NHS Trust

Investigators

  • Study Chair: Norah Flannigan, University of Sheffield

Publications and helpful links

The person responsible for entering information about the study voluntarily provides these publications. These may be about anything related to the study.

General Publications

Study record dates

These dates track the progress of study record and summary results submissions to ClinicalTrials.gov. Study records and reported results are reviewed by the National Library of Medicine (NLM) to make sure they meet specific quality control standards before being posted on the public website.

Study Major Dates

Study Start (Estimated)

March 1, 2025

Primary Completion (Estimated)

March 1, 2026

Study Completion (Estimated)

March 1, 2026

Study Registration Dates

First Submitted

March 28, 2024

First Submitted That Met QC Criteria

March 28, 2024

First Posted (Actual)

April 3, 2024

Study Record Updates

Last Update Posted (Actual)

March 25, 2025

Last Update Submitted That Met QC Criteria

February 28, 2025

Last Verified

December 1, 2024

More Information

Terms related to this study

Keywords

Other Study ID Numbers

  • 187157
  • 340246 (Registry Identifier: Integrated Research Application System)

Plan for Individual participant data (IPD)

Plan to Share Individual Participant Data (IPD)?

UNDECIDED

Drug and device information, study documents

Studies a U.S. FDA-regulated drug product

No

Studies a U.S. FDA-regulated device product

No

product manufactured in and exported from the U.S.

No

This information was retrieved directly from the website clinicaltrials.gov without any changes. If you have any requests to change, remove or update your study details, please contact register@clinicaltrials.gov. As soon as a change is implemented on clinicaltrials.gov, this will be updated automatically on our website as well.

Clinical Trials on Time

Clinical Trials on Alginate impression

Search Similar Trials

Sponsors and Collaborators

Medical Conditions

Drug Interventions

CROs by country

CROs in Vietnam

Conditions

Rare Diseases

Drug Interventions

Dietary Supplements

Sponsor/Collaborators

Locations

Subscribe